| 低锌活性剂SA-1替代氧化锌在丁苯橡胶胶料中的应用 |
| Application of Low Zinc Activator SA-1 to Replace Zinc Oxide in SBR Compound |
| 投稿时间：2021-10-17 修订日期：2021-10-17 |
| DOI：10.12136/j.issn.1000-890X.2023.03.0201 |
| 中文关键词: 低锌 活性剂SA-1 氧化锌 丁苯橡胶 耐热空气老化性能 抗湿滑性能 滚动阻力 |
| 英文关键词: low zinc activator SA-1 zinc oxide SBR hot-air aging resistance wet skid resistance rolling resistance |
| 基金项目:国家自然科学基金资助项目（21838003，91834301）；中央高校基本科研业务费专项资金资助项目（222201718002） |
|
| 摘要点击次数: 2006 |
| 全文下载次数: 1071 |
| 中文摘要: |
| 采用低锌活性剂SA-1作为丁苯橡胶（SBR）胶料的硫化活性剂，研究其用量对SBR硫化胶物理性能、耐热空气老化性能和动态力学性能的影响，同时与普通氧化锌997进行对比。结果表明：活性剂SA-1在SBR基体中的分散性优于氧化锌997；活性剂用量较大（3～5份）时，采用活性剂SA-1的SBR硫化胶具有较出色的物理性能和耐热空气老化性能；随着活性剂SA-1和氧化锌997用量的减小，SBR硫化胶的物理性能和耐热空气老化性能均有下降，与氧化锌997相比，活性剂SA-1可以在用量更小时保持SBR硫化胶的物理性能；采用活性剂SA-1的SBR硫化胶具有更好的抗湿滑性能，同时滚动阻力无明显增大。 |
| 英文摘要: |
| Low zinc activator SA-1 was used as the vulcanizing activator of styrene-butadiene rubber
（SBR） compound，and the effects of its amount on the physical properties，hot-air aging resistance and
dynamic mechanical properties of SBR vulcanizate were studied and compared with ordinary zinc oxide 997.
The results showed that the dispersibility of activator SA-1 in the SBR matrix was better than that of zinc
oxide 997.When the amount of activator was large（3 ～ 5 phr），the SBR vulcanizate with activator SA-1
had excellent physical properties and hot-air aging resistance.With the decrease of the amount of activator
SA-1 and zinc oxide 997，the physical properties and hot-air aging resistance of the SBR vulcanizate were
decreased. However，compared with zinc oxide 997，activator SA-1 could maintain the physical properties
of the SBR vulcanizate when the amount of activator was small. It was also found that by replacing ordinary
zinc oxide 997 with activator SA-1，the wet skid resistance of the SSBR vulcanizate was improved，while the
rolling resistance did not increase significantly. |
|
|
查看全文
查看/发表评论 下载PDF阅读器 |
| 关闭 |
