文章摘要
溶液法丁基橡胶硫化胶囊的研制
Development of Solution Butyl Rubber Based Curing Bladder
  
DOI：
中文关键词: 溶液法  淤浆法  丁基橡胶  硫化胶囊
英文关键词: solution method  slurry method  IIR  curing bladder
基金项目:
作者单位
刘志琴 中国石油兰州石化公司 研究院 
苟发荣 中国石油兰州石化公司 研究院 
胡开放 中国石油兰州石化公司 研究院 
焦宏宇 中国石油兰州石化公司 研究院 
刘秀兰 中国石油兰州石化公司 研究院 
潘广勤 中国石油兰州石化公司 研究院 
摘要点击次数: 1072
全文下载次数: 471
中文摘要:
      分别以淤浆法和溶液法丁基橡胶（IIR）制备全钢载重子午线轮胎硫化胶囊，并对其性能进行对比研究。结果表明：采用硫化胶囊标准配方，淤浆法IIR硫化胶的物理性能较好，溶液法IIR硫化胶的耐热老化性能较好且硫化时间较短；采用硫化胶囊生产配方，溶液法与淤浆法IIR硫化胶物理性能相差不大，溶液法IIR硫化胶的耐热老化性能较好。两种IIR硫化胶囊质量相当，均达到了工厂使用要求。
英文摘要:
      The truck and bus radial tire curing bladders were prepared by using slurry and solution IIR respectively，and their properties were investigated.The results showed that， when standard formula was used，the physical property of slurry IIR vulcanizates was better，the optimium cure time of solution IIR was shorter，and the heat aging property of solution IIR vulcanizates was better.When production formula was used， the physical property was similar，and the heat aging property of solution IIR vulcanizates was better.The qualities of these two IIR based curing bladders were similar，and both of them met the operational requirement for factory.
Author NameAffiliation
LIU Zhiqin Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
GOU Farong Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
HU Kaifang Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
JIAO Hongyu Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
LIU Xiulan Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
PAN Guangqin Research Institute of Lanzhou Petrochemical Corporation of PetroChina 
查看全文   查看/发表评论  下载PDF阅读器
关闭